Electric Vehicles Troubleshooting Guide

Find Your Product:

Guide 1

Model #903 & #904

Guide 2

Model #906

asdf

All Guidelines Battery Guidelines Vehicle Care
Safety Guidelines Troubleshooting  

All Guidelines

Battery Guidelines

Battery Warnings

WARNING:
TO PREVENT FIRE, EXPLOSIONS OR SERIOUS INJURY

  • Read the safety instructions on the battery.
  • Examine the battery, charger, and all connections for excessive wear or damage before each use. Do not use if damage or wear is found. Replace immediately.
  • Always secure the battery using the battery retainer.
  • Only carry the battery by holding onto the main casing.
  • Never modify the electrical system.
  • Use only Radio Flyer battery and charger specifically meant for this product.
  • Do not use Radio Flyer components in other battery operated vehicles/toys.
  • Do not touch motor after prolonged periods of use. Motor housing may be hot. Handle carefully.

DANGER/POISION:

  • The battery contains chemicals known to the State of California to cause cancer and reproductive harm. Wash hands after handling.
  • The battery contains corrosive acid that can cause blindness or burns. Contact physician immediately if exposed.
  • Keep out of reach of children.
  • Do not open battery.

CAUTION:

  • Use the charger in dry locations only.
  • DO NOT incinerate used batteries.
  • DO NOT dispose of batteries in fire.
  • DO NOT mix old and new batteries or types of batteries.
  • DO NOT use rechargeable batteries.
  • DO NOT recharge non-rechargeable batteries.
  • DO NOT short-circuit the supply terminals.
  • Different types of batteries should not be mixed.
  • DO NOT mix old and new batteries or types of batteries.
  • Only batteries of the same or equivalent type as recommended are to be used.
  • Exhausted batteries should be removed from the toy.
  • Dispose of batteries safely.
  • To prevent electric shock, do not immerse in water; wipe clean with a damp cloth.
Battery Care

  • The battery must be handled by adults only. The battery is heavy and contains sulfuric acid.
  • If the battery begins to leak, avoid contact with the leaking acid and place the battery in a plastic bag. If acid comes in contact with skin, eyes, or is internally ingested contact a physician immediately. See section titled “Battery Disposal” for proper disposal instructions.
  • Never allow the battery to discharge completely. Battery should be charged before it is completely drained.
  • Charge the battery before storing the vehicle.
  • Fully charge the battery at least once per month, even if the product hasn’t been used. Leaving the battery in a discharged state can shorten the life of the battery.
  • Charge the battery after each use, regardless of how long the vehicle was used.
  • Store the battery in temperatures between 35 °F (1.7 °C) and 77 °F (25.0 °C) for optimal performance.
  • Never charge the battery longer than 18 hours. Failure to follow these instructions may damage your battery and will void your warranty.

Battery Charging

Red Light: Charging - Do not ride.
Green Light: Fully Charged - Ready to ride.

  1. Only use the provided Radio Flyer 6 volt charger to charge the 6 volt battery. Power source or wall outlet must be 120 VAC and 60Hz. If the wall outlet is controlled by an on/off switch ensure that the switch is on.
  2. Charge the battery until the LED light located on the charger changes from “Red” to “Green”. The green light indicates a fully charged battery. Charge the battery after every use.
  3. Never charge the battery longer than 18 hours. Failure to follow these instructions may damage your battery and will void your warranty.
  4. Once the battery is completely charged, disconnect the charger from the wall outlet and remove the charger plug from the charging port located near the back of the vehicle.
  5. The battery does not need to be removed from the vehicle. Keep the battery in the rear compartment when charging.
  6. Before charging the battery, examine the battery case for cracks and other damage which may cause sulfuric acid to leak. If damage is detected, please call Radio Flyer Customer Service immediately and do not use the product any further.

Battery Disposal

  1. Recycle or dispose of non-spillable sealed lead-acid battery in an environmentally sound manner.
  2. Do not dispose of your lead-acid battery in a fire. The battery may explode or leak.
  3. Do not dispose of your lead-acid battery in your regular household trash. The incineration, landfilling, or mixing of sealed lead-acid batteries with household trash is prohibited by law in most areas.
  4. Return an exhausted battery to a federal or state approved lead-acid battery recycler, such as a local seller of automotive batteries. Contact your local waste management officials for other information regarding the environmentally sound collection, recycling and disposal of lead-acid batteries. If you live in the State of Florida or the State of Minnesota, it is prohibited by law for anyone to throw away lead-acid batteries in the municipal waste stream.